Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace - Car Batteries

I have taken it off the car, and the first thing I did was to check the brushes, they appear good, still very long and retracting and springing back as they should. Felcia just read an Poqer on repair and diagnosis Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace alternator faults.

Alternator stripdown and repair. As it happens before I removed the alternator I charged the battery to do some tests with the engine running. Put on Feoicia demister and headlights, voltage on battery rapidly decreases by 0.

Also mentions on Rovers a amp fuse that can be blown in Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace of no battery charging at all OR any further tests I should do on the removed alternator or refit the alternator to do any further tests, refitting it temporarily will be fairly easy so no problem for me to do.

So I am fairly limited to choice as far as the scrap man is concerned Can I take it to a Lucas shop, and will they be able to do a hopefully free diagnosis check so I can order the correct part that has failed eg rectifier. Also What would be the symptoms of a voltage regulator failure?

Any tests I could do to determine if it was that instead Battety the Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace Voltage Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace is relatively cheap and easy 50Au replace.

I thought he Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace a seperate thingy on the side of the engine compartment.

Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace

Still in the dark as to how to 79 which part of the alternator is at fault. Don't want to change the regulator brush box, and then find the problem still there and maybe the Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace. Just had the same problem on my 1.

It's quite rare for the actual alternator to go wrong, it's nearly always the regulator that fails. It's held on with 2 screws and takes virtually no time to replace.

You don't even need to remove the alternator. Quick update, I already have it off the car, but I realised I messed up when I tested it on the car Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace, so when I get around to it Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace will be refitting it to the car to do a proper test.

I also found out about bench testing the regulator. For a 3 terminal'd regulator, you need to identify which terminal. The left one as you view the regulator from. So far I also have some insight into testing the rectifier, you have to dismantle the alternator, de-solder the rectifier from the windings 3 of them apparently then test the individual diodes with appropriate multimeter.

Also discovered, testing the regulator Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace the car, Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace the ignition off, move a screw driver near to the pulley centre nut, you should feel no magnetic field affecting the screwdriver blade.

Now turn on ignition without starting the car. After a short time you should now feel a magnetic field pulling on Bsttery blade, you Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace also hold Pkwer screwdriver at the rear of the alternator, in the centre of the rear near the regulator box, think of the centre line axis through the alternator from the pulley through to 194-2002 back of the alternator.

Should Bxnner the same effect at that end. Although why this indicates a broken regulator and not a broken rectifier, beats me, IMO it could be. I just Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace this on a good car, and the magnetic pull is very slight but it's.

I had no luck getting a regulator, no motor factor sells Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace, some Bulll they hadn't seen or heard of them for years.

Even an auto electrics supplier could not get one. The local LSUK centre has also closed. Had no luck finding an alternator in about 8 scrapyards. One scrappy noted its similarity to a Mk1 Ford fiesta, he showed me one, and I agreed, but I didn't opt to buy it until I did some further price searching. Wood Auto Supplies Ltd:: Then I have to make a spacer about 12mm thick for the mounting bolt to go through, and also put the skoda pulley onto the Ford alternator.

I bored Metrocab Taxi 1991-2006 Bosch S4 Battery 95Ah Electrical System Replacement Part the internal diameter of my pulley by only about 3 thousandth of an inch using a lathe and it went on easily. The pivot bolt on the Batteyr is M10, the Ford is M8 so you will need an M8 bolt of the same length or slightly longer.

The rear pivot 'leg' on the Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace comes with a M8 bush inside 20mm long you can see it in the picture on the woodauto page aboveyou need to cut this down to 15mm - hacksaw or lathe or make a new spigot one on lathe - you should cut this bush kM2 making the spacer detailed below, and measuring the Hopefully you will understand and work it out when you do this.

Now Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace need to have a gap of Now all you need is to remove the spade connector from the warning lamp wire and replace it with a crimp ring connector, or use a small piece of wire 20mm long with a male spade on one end and a ring on the. Battety warning lamp smaller wire now Feliciia a ring terminal goes onto the small screw thread mounting in the roughly the same location as the spade terminal was on the Skoda Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace. You attach nothing to the Ford 'W' RReplace.

The only thing I didn't think about was the M8 bolt passing through the engine mounting bracket which has M10 holes for the Banenr bolt Skora, it would be best if you could make a sleeve with an Bzttery diameter the same as the M10 bolt about 9.

Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace

I can't think of anything off the top of my head that would do the job. But it would Rplace to make the alternator a lot more secure. Hi Temps, Where in the country are Skodx, I could make a sleeve for you if required. You could also try asking at a model engineering club if there's one near you. If you want me to make a sleeve for you PM me. Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace first pic shows the Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace you will need to make.

Part 'B' is the spacer, it is important because it will position the pulleyit doesn't have to be round, you can use anything you want that is strong and about It should be I made part 'D' because I wanted to keep Mazda Demio Dw 1998-2003 Bosch S4 Battery 45Ah Electrical System Replace Part part 'A' intact.

Part 'A' is a bush that comes fitted to the ford alt, and I didn't want to cut Banmer incase I had M2 return the alternator. To clarify you only need part 'A' or part 'D" not.

Part 'C' is a sleeve Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace the M8 bolt, it's best if you can get one but not essential if you tighten the bolt hard. I used a piece of pipe I found that was almost perfect. One idea I had was to use the sleeve from an M8 masonry rawllok, and turn it down to 9.

Has to be 65mm length. This one shows the general assembly of the parts. Ignore the washer on the rightI just had that to try to fill in a gap I had because my part 'B' is This one is the pivot assembled on the car, minus the washer, I decided to leave it out, this might put a little strain Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace the alt's 'legs' as they are squeezed to take up the slack Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace the 83mm gap, which is why you should have a spacer This one shows that you have to pack out the adjuster nut, because a gap is created, using the ford alt.

You see I have a washer or two, I would have put two but I only had one spare I suggest you put two in the central gap between the alt and the adjustment slide. I recently Titanium 075 Car Battery 12V 62Ah 520CCA my voltage regulator. If this isn't happening then it sounds like you have a fudged battery.

If it is happening I can put you on to a reputable supplier of skoda electric parts. I believe mine was a faulty Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace, the symptoms you describe indicate a Baftery output that increases with revs and not limited to Mine had no voltage output at any revs.

Where did you get your new regulator from and how much was it? I found them impossible to find, either in scrap yards or from motor factors. Still an expensive mistake Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace make.

A mistake this guy on ebay made aswell. I've been looking for regulators as. Had Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace given up trying to find them but there are some at the link.

Hope the Fdlicia helps in future. A voltage Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace is an electrical regulator designed to automatically maintain a constant voltage level.

The regulator on alternators 1949-2002 also responsible of maintaining a proper battery charging current, higher when battery is depleted and lower when fully charged. Those being said, the easiest way to identify a faulty regulator is to measure the voltage across the battery while engine is running.

A typical voltage should be For instance, when the regulator is fried, the higher the engine speed, the brighter the lamps get, the quicker the wipers move. You need to be a member in order to leave a comment. Sign up for Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace new account in our community. Already have an account? Posted 11 February, edited.

Alternator stripdown and repair How it works As it happens before I Banner the alternator I charged the battery to do some tests with the engine Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace. Started car, battery warning light and ignition light both stayed on constantly 2 red lights Voltage of battery drops at a slow rate with no load on the engine engine running Put on rear demister and headlights, voltage on battery rapidly decreases by 0.

Thanks Edited 11 February, by temps. Share this post Link to post Share on other sites. Posted 11 February, The regulator is built in Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace the alternator, Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace can be replaced seperately. Personally, I'd take the unit you have to a reconditioner and have it rebuilt and tested. Edited 11 February, by cjb.

Car Batteries | eBay

Posted 12 February, Posted 12 February, edited. Hi guys Quick update, I already have Skoda Felicia 6U1 6U5 797 Mk2 1994-2002 Banner Power Bull 50Ah Battery Replace off the car, but I realised I messed up when I tested it on the car before, so when I get around to it I will be refitting it to the car to do a proper test.

Edited 13 February, by temps.

Leave a comment